Jump to content

Making watch case gaskets.


Recommended Posts

I've got an unusual size gasket (31.6mm inside diameter x 34.8mm outside diameter x 0.5mm) that I can't find on Cousins so I decided to try and make my own.

I bough two A4 sheets of 0.5mm thick nitrile rubber, an Olfa compass cutter and a cutting mat. I didn't think it would be easy and I wasn't wrong. After about 20 attempts I think I've managed to make a suitable gasket...

The gasket on the left is the original, the middle one is my best and the one on the right is uneven.

The best technique I could come up with is to cut a square of rubber and stick it to the cutting mat with double sided tape. After honing the blade once I cut out the largest diameter. Then, after honing the blade again I cut out the inner diameter. I then carefully removed the outer rubber then inner rubber.

There are better cutters online but they're pretty expensive and there's no guarantee they'd cut better.

Not sure if I'd ever need to make another but any tips would be appreciated.IMG_20210711_145334.thumb.jpg.89e929baec5eaac1561af2ff89fae9d6.jpg

  • Like 2
Link to comment
Share on other sites

The way I've made gaskets in the past is with a punch. You'd need a circular blade cutter of the exact OD/ID size though... I've not seen them that large, nor have I seen them adjustable.

This may border on heresy, but what about RTV? I assume there's a channel for the gasket. A fine layer of grease on one face will allow it to release. 

Another may be to 3d print a gasket mold, then fill it with RTV or two part silicone...

I'm sure there are other ways as well...

  • Like 1
Link to comment
Share on other sites

1 hour ago, spectre6000 said:

The way I've made gaskets in the past is with a punch. You'd need a circular blade cutter of the exact OD/ID size though... I've not seen them that large, nor have I seen them adjustable.

This may border on heresy, but what about RTV? I assume there's a channel for the gasket. A fine layer of grease on one face will allow it to release. 

Another may be to 3d print a gasket mold, then fill it with RTV or two part silicone...

I'm sure there are other ways as well...

Does RTV set? Could I form some sort of mould to the correct dimensions? 

I can't see dies/punches working for me due to the cost.

Link to comment
Share on other sites

2 hours ago, Plato said:

Does RTV set? Could I form some sort of mould to the correct dimensions? 

Yes. Not sure what country you're in, but pick a FLAPS (Friendly Local Auto Parts Store), and peruse the chemical section. Permatex is the brand I usually see around here. There are different formulations for different applications; most of which aren't exactly applicable. The baddest stuff going is the Ultra Black formulation, but watches are a different kind of engine...

You'd need to make a set of ID/OD forms, and plan for some sort of release strategy... Cooking spray maybe? Teflon? Then goop it in, and scrape off the excess with a razor blade or some such. It'll stay pliable and resistant to oil/water for a good long while in conditions far beyond what any watch would have thrown at it.

  • Like 2
Link to comment
Share on other sites

I've made gaskets and valve parts from dental impression silicones. Some of them were used in extremely harsh environments, like the insides of an autoclave, and they performed better than the original part.

I recently restored a Bulova Accuquartz 224. The gasket had expanded and was very difficult to reseat. I tried cutting my own gasket with a similar circle cutter but the blade tends to go off on a tangent ( literally ). Esslinger had the gasket for $6.95 but the shipping cost to Singapore was $36. I ended up buying from a seller on ebay. 

  • Like 1
Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Restore formatting

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.



  • Recently Browsing

    • No registered users viewing this page.
  • Topics

  • Posts

    • Even for myself who only started getting into watch repair/servicing during COVID I have seen a huge jump in watch prices - we have a 404 channel on this forum. When I started you could relatively easily find a watch on eBay to restore and put onto the channel, however this is now almost impossible and the only feasible solution is to buy a job lot with an average price <4.04. Even watches sold for parts/spares are 3 or four times the price of only a few years ago. Why - Either Demand must have increased in order to push up the price, or supply is reduced. I think it is a little of both, I think that most watches in the UK/US may have been picked over, which agrees with most of what @Neverenoughwatches says so supply of all kinds of vintage watches, including tat is dwindling. As a double whammy I think that more people are wanting watches, either to work on, or as a way to differentiate themselves from the Apple Watch and FitBit crowd. The upshot is that half decent watches that require restoration are now $500 instead of $100 and cheaper watches (Seiko 5 etc) are now $50 instead of $10, and even Mumbai Specials and garbage are now pushing $50 each. When - how long will this last, I think that most of the people who are returning to mechanical watches are those that have previously experienced life without them and want to return to something with a bit of personality that doesn't buzz every 10 seconds on your wrist and tell you how many steps you have done today. i.e. the 30-40+ generation. My son who is 17 has several mechanical watches but only wears one on a special occasion and is obviously only aware of them at all in part due to my hobby. I asked him the other day how many of his friends wear a watch and he told me that some use a smart watch but most just use their phones. So as I see it, demand will start to fall once the sub-thirty crowd start becoming the majority and/or the older amongst us stop buying watches and switch our attention to mobility scooters and trying to remember our bank password. Price - I think this is here to stay, even if demand does start to drop as the older generation becomes to decrepit and stops buying and the younger generation isn't interested in buying, supply will become progressively less as time goes on as more vintage watches become lost or broken beyond repair. I think the prices will plateau at some point as an equilibrium is reached as reduced demand is balanced with reduced supply, i.e. less and less people buying less and less watches. Sorry for the long ramble!
    • Hi. Use a PVA based glue, gorilla glue it dries transparent then do as advised by Old Hippy, smoothe down using very fine  0000 wire wool and either French polish or beeswax for a finish.
    • Hello and welcome to the forum.    Enjoy
    • The problem with oil in particular 9010 is it likes to spread. This is why you're supposed to use epilam anywhere it's used to keep the oil in place. Then you want to splurge on money you could buy 941 it's actually an oil that existed before 9415. Then the problem with the grease yes it stays in place but if you have too much you lose amplitude. Then if you get really obsessed with this he would follow Omega's recommendation for escapement lubrication. One of the problems with internal documents of the watch companies is typically are never going to see Them.But a few of them out in the wild for instance at this link Below I searched for the keyword of working. In particular working instructions of the Omega watch company for which there is way more than This but this is all they have. So you want to download number 40 as were going to talk about that and also download Number 81. Plus anything else that looks interesting https://www.cousinsuk.com/document/search?SearchString=Working Then number 40 covers lubrication of the watch. Most interesting is lubrication of the lever escapement under three different conditions with Lubrifar Which you probably no longer have has been washed off without which is what you have and then a course with epilam. Notice how they go supers super minimalistic with the 9415 because if it's too heavy you lose amplitude. Then if you lose amplitude the group will be disappointed with you and the end of the world will come.      
    • You would always get an answer John, you dont need to be dramatic or humerous to get one, but it was appreciated anyway 🙂 Kind of, for those of us that wish to stay in touch and continue to learn from each other in case the forum ever dissappears then yes i suppose so . I  hope that you would also count yourself in , what we learn from you is invaluable,  how you benefit from that exactly I'm not sure, being able to teach ? I did say is it ok to ask mark for some input John and suggested that he might read the thread that explains how some of us feel. I dont see how its really discussing forum policy, but in all honesty i wish i had never even bothered now.
×
×
  • Create New...