Jump to content

Let’s hear your super tips for a great workstation!


Tudor

Recommended Posts

I think lots of people will benefit from this thread, but I have been banished to the basement with my collection of tools and junk.

so, I have a blank slate. The chance to do it right. I have some ideas of my own but I’m keen to hear what works well for you and why. 

Let’s get this rolling!

Edited by Tudor
Link to comment
Share on other sites

Well, lighting is top of my wish list. I will Be under a large (for a basement) window, and I am considering angled mirror(s) to reflect light from the high window down onto my work surface. 

In addition, I am hoping for three four-foot LED shop lights- one over head and on on the left and right, long ways, to flood the Work area from three directions. Plus I have my IKEA halogen desk lamp. 

The bench was going to be an older IKEA desk I have in pieces, but the height doesn’t adjust as I thought it did, and I can’t find the hardware to build it again. So that top is going to go on top of some 2x6 lumber (flat) which is on top of an unused dining room table in the basement. So I’ll be about three inches higher than a normal table. I may make a riser out of 2x4’s on edge to give 4-1/4” over table height. I have to see what works. I’m 6-2” so it may go up even higher...

Link to comment
Share on other sites

Yes I'm still struggling on a desk that is too low, I have a good stool that goes lower than normal which helps, but a higher desk would be much easier.

If you in a basement how is the ventilation and humidity control?

Ventilation as I am thinking about your cleaning fluids and humidity control so you don't have to worry about rust.

Very few houses in Australia have basements, so its not really an issue I have had to deal with but I have friends in the UK that needed to install dehumidifiers to make his basement suitable as a workshop.

Link to comment
Share on other sites

We are fortunate in that we have central air for the house, which dehumidifies the entire house. But, it does not cover the basement... Therefore, I have a dehumidifier running 24-7 down there, as I have my drums in a small room (the "Drumgeon") down there too.

It is always cool, so the dew point is generally not an issue even though relative humidity is a bit higher than I'd like. I also have a pile of exotic wood from my guitar making days that also prefers is moderate and fortunately no issues with growing stuff on any of that.

And I've been sniffing solvents my entire life (model building when younger, industrial work for 30 years and auto repair and restoration in between) so that doesn't bother me. I do have a serious exhaust fan set up in the Drumgeon as it gets quite warm in there, which would pull out any heavy build-up of smells.

Link to comment
Share on other sites

as beginner, losing/dropping parts is all too frequent and a royal PITA.  A floor that's easy to spot stuff on, a  bench with groove along the front and pull out cloth tray all help.  My bench also has a glass cover, basically like a large upside down three sided fish tank with the front open.  It minimizes dust settling and has stopped a few parts that go zinging out of a too-firm tweezer grip

Edited by measuretwice
Link to comment
Share on other sites

I was actually thinking a frame on the outer edges that could support and old sheet or plastic would be a good idea to keep dust off all surfaces when I'm not working, not just the critical parts in boxes or under covers.

But if I'm working on something "new" to me, I will sometimes use a piece of plastic wrap to control flying parts. When I know something may fly, I try to stick some rodico on it, so the mass is greater and it can fly as far. (if at all).

Some great food for thought! Lets keep the ideas flowing!

Link to comment
Share on other sites

I always where an old hardware store Apron I have a grommet at each bottom corner , and two hooks under my bench . When I sit down to work , I hook them up  & there is a nice sling to catch things.

Just don't forget to unhook yourself when you get up to go pee.  :)

 

20180813_153946_resized.jpg

20180813_154052_resized.jpg

Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Restore formatting

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.



  • Recently Browsing

    • No registered users viewing this page.
  • Topics

  • Posts

    • I looked at it like this, I've built a lot of stuff in my time, building structures and furniture,those are my creations and they will still be here way way after I'm gone. Traditional watchmakers felt the need to pass their knowledge on, ideas that they created . I assume with them as it is with me, leaving their mark on the earth, a way of being remembered. This creation of Mark's has brought thousands of people together to pass their knowledge around,  ideas that will continue to be used for lifetimes. Ideas that should continue to be procured. If for whatever reason the forum ceased to exist, not quite like Ranfft's, that didn't disappear but much less usable. Then that is sad, such a massive loss of communication between good people and a wealth of knowledge lost. There should be something in place for when that happens which could be next week, next year or in 10 years. Might not be a topical subject for a lot of folk or boardering on controversy, i did say i talk about stuff other people dont. But if you dont talk about it and something happens then you've lost it and you ain't gonna fix it .
    • I've remained silent on this thread, and at the risk of upsetting everyone, the thing that worries me the most the the apparent absence of Mark. The moderators do a great job and the members also pitch in, and the site seems to run itself, but it is a concern for the future of this forum when the owner is absent for all intents and purposes. Like many of the comments above I would hate to log in one day and things be closed down as I rely on this site for ideas and knowledge and also cheer me up. maybe the Moderators could reach out to him, assuming he does not read this thread, and express our concerns and let us know the plans going forward? some kind of WRT ark
    • That was the exact reason for me starting this thread watchie. Still we haven't worked out how the regulars are going to hook up if it goes tits up. I honestly think something should be arranged to stay in contact, we all help each other so much. 
    • Yeah ive watched that a few times before,  i couldnt find my old school dividers to scribe it up 😅 Yep thats the guy i bought a roll from . Thanks Nicklesilver that answers that perfectly and more or less what i thought an experiment over time would prove . The jumper arm is quite thick along its length, i left it that way intentionally, i thought the original was probably very thin, i didnt see that it was already missing. Setting isn't particularly stiff as such just positive, i still need to take it out and polish where it mates with the stem release. 
    • Yes, "Sold out" is difficult to understand. There doesn't seem to be a lot going on. It's been nine months since any new video was published on the Watch Repair Channel. The Level 4 course on watchfix.com has been in progress for what feels like forever (several years!?). Maybe Mark's enterprises aren't doing well or perhaps already so profitable there's nothing much to motivate him for more material. Or, perhaps these days he's more into crochet. The real reason is probably something entirely different but it would be nice/interesting to know. I don't mean to sound gloomy or pessimistic, but I wouldn't be surprised to be met by an HTTP 404. Every day feels like a gift. Speaking of watchfix.com I've been postponing the "Level 5: Servicing Chronograph Watches" course for a very, very long time. Anyway, I just enrolled on it so it's going to be very interesting to see the videos. I must say, IMO there's nothing really that can compete with Mark's courses when it comes to presentation and video quality. It's simply world-class and makes me associate with some really expensive BBC productions.
×
×
  • Create New...