Jump to content

balance wheel wobble


Recommended Posts

I've started trying to replace balance staffs in pocket watches. My first victim is an Elgin 0s model 2.  I've got the correct tools for the job. Disassembly went fine, but after installing the new staff the balance wheel now has a slight twist to it and wobbles. I "tried to fix it" with a pair of parallel pliers but have only made it worse.  It is now also out of balance.

My questions are, What did I do to cause this?  What steps should I take to avoid it again? Lastly how do I fix this one?

Thank you in advance,

Nora

  • Thanks 1
Link to comment
Share on other sites

7 minutes ago, Nora said:

I've started trying to replace balance staffs in pocket watches. My first victim is an Elgin 0s model 2.  I've got the correct tools for the job. Disassembly went fine, but after installing the new staff the balance wheel now has a slight twist to it and wobbles. I "tried to fix it" with a pair of parallel pliers but have only made it worse.  It is now also out of balance.

My questions are, What did I do to cause this?  What steps should I take to avoid it again? Lastly how do I fix this one?

Thank you in advance,

Nora

Hi Nora,

There are actually a couple other threads here of people who went through the same thing, that is wobble after replacing a balance staff. Here is one:

 

Another thing I can think of is maybe the wheel was damaged process of replacing the balance staff and needs to be poised. Here is an article talking about checking poise and poising a balance wheel:

https://www.great-british-watch.co.uk/how-to-poise-a-balance-wheel/

Hope this is helpful!

  • Thanks 1
Link to comment
Share on other sites

1 hour ago, spectre6000 said:

Jump in the deep end! That's how winners roll! That's also how you break things, but you learn more and more quickly that way. Kudos.

The deep end is an illusion. You can float in 3 feet of water and not touch the bottom doing so. You can float in 300 feet of water and never touch the bottom. Both feel the same way, so it then comes down to how far from shore do you feel comfortable being.

Cheers!

  • Haha 1
Link to comment
Share on other sites

Hi well done so far Now you need to learn trueing the balance in the calipers and poising the balance.  Firstly you need a pair of truing calipers or a truing jig so as to get the rim running flat then poise the balance in the jaws to check if there are heavy point, either of these being out of true will affect the timing rate . Pictures of the tools  below.:thumbsu:

s-l1600 (1).jpg

s-l1600.jpg

  • Thanks 1
Link to comment
Share on other sites

14 hours ago, HectorLooi said:

What method did you use to remove the old balance staff? Did you use a Platax tool, K&D balance staff remover or did you cut the rivet off on the lathe?

I have an "Automatic Balance Staff Remover" made by the M-B Tool Manufacturing Co. Sorry about the picture quality. I only have my what's only phone.

20200721_121957.jpg

20200721_123048.jpg

20200721_123114.jpg

20200721_123141.jpg

Link to comment
Share on other sites

watchweasol

I won this on auction a couple of days ago. It is on it's way. I suspect that the set screws are missing judging by the picture on the box, but I can sort that out once it gets here. It otherwise looks complete to me. I'd eventually also like to get the other model you show but is not in the foreseeable future. An ultrasonic cleaner will come first.  

s-l1600.jpg

Link to comment
Share on other sites

17 hours ago, Nora said:

I watched Mark's video on it twice and thought I can do that, so I did. :unsure:

Good for you, that attitude will take you a long way! Personally, I've been doing this for a few years now but so far I've only dared to secretly think about balance staffs a little. ;)

Link to comment
Share on other sites

1 hour ago, VWatchie said:

Good for you, that attitude will take you a long way! Personally, I've been doing this for a few years now but so far I've only dared to secretly think about balance staffs a little. ;)

I offer this to you as encouragement. Stop just secretly thinking about it.  Buy a watch with the part you want to work on already broken and give it a try. you will get one of two results. It will still be broken in the same way as you started with or it will work out. I call it the rule of 50. 50% it will, 50% it won't. It's like the old adage "you won't  know till you try. Worst case scenario, you try it and don't like it. In that case resell the movement and the tools for what you have into them, and move on. 

  • Like 5
Link to comment
Share on other sites

24 minutes ago, Nora said:

I offer this to you as encouragement.

Thank you @Nora! My post was meant as a friendly encouragement as well but I don't think it came through all that well. I'm deeply impressed that you would go for this rather tricky operation so soon. Watch repairing has many, many challenges, and I guess it takes a while before you've taken on most of them. Next on my list of challenges will be dynamic posing and resetting/adjusting pallet stones. Before this I was happy to succeed with replacing jewel bearings, adjusting end shake, and adjusting a hairspring. "They" say there's nothing magical about mechanical watches and Precision Mechanics, but I somehow hope I'll never get to realize it :lol:

Good luck! :thumbsu:

  • Like 1
Link to comment
Share on other sites

1 hour ago, rodabod said:

Did you bend the arms or the rim? Or both. 

I'm not sure. I took the staff back out and set it on the staking table. This is obviously  not to scale but an approximation of what I see. The actual gap I'm guessing to be about .002" /  .051 mm. It was a lot worse with the staff in.001.thumb.jpg.d2d1e737ce7b8b17a137401a13938eb8.jpg

Link to comment
Share on other sites

1 hour ago, rodabod said:

Did you bend the arms or the rim? Or both. 

I start with the arms and some finishing touch on the rim. 

In case the wheel is out of round, a truing caliper is neccessary. 

  • Thanks 1
Link to comment
Share on other sites

10 minutes ago, jdrichard said:

So. Would you like me to make a video on how to straighten a Warped or Fouled balance using the proper calipers; etc?

I did that for the first time a short time ago, at Master's workshop. Balance wheel alone, he handed me some sort of calipers with bronze (?) jaws, told me to hold the balance tight in one hand, grab the spoke that shows as high on the huit-ciffre, pull down a bit. So I did and after checking it was deemed "not so bad"  :biggrin:

Edited by jdm
Link to comment
Share on other sites

I did that for the first time a short time ago, at Master's workshop. Balance wheel alone, he handed me some sort of calipers with bronze (?) jaws, told me to hold the balance tight in one hand, grab the spoke that shows as high on the huit-ciffre, pull down a bit. So I did and after checking it was deemed "not so bad"  :biggrin:

I have done this number of times. First, years ago, it was a balance that I warped by tapping too hard when installing a staff. Then it was the occasional balance in pocket watches I was repairing that were “out of round” and also not flat. I got pretty good at Rounding and flattening balances. As well, I have had to flatten the arms in a staking set prior to bending the balance back to true. I have also adjusted the balance of the balance with the screws and washers. I have also undercut screws to adjust the weight. So I thought a video on this topic with some discussion on how not to screw it up in the first place, followed by how to fix it.730460198eccf576961e91123887c6d5.jpg
And I have fixed a few.


Sent from my iPhone using Tapatalk Pro
  • Like 3
Link to comment
Share on other sites

20 minutes ago, jdrichard said:

So. Would you like me to make a video on how to straighten a Warped or Fouled balance using the proper calipers; etc?


Sent from my iPhone using Tapatalk Pro

That would be very helpful. 

Link to comment
Share on other sites



  • Recently Browsing

    • No registered users viewing this page.
  • Topics

  • Posts

    • I looked at it like this, I've built a lot of stuff in my time, building structures and furniture,those are my creations and they will still be here way way after I'm gone. Traditional watchmakers felt the need to pass their knowledge on, ideas that they created . I assume with them as it is with me, leaving their mark on the earth, a way of being remembered. This creation of Mark's has brought thousands of people together to pass their knowledge around,  ideas that will continue to be used for lifetimes. Ideas that should continue to be procured. If for whatever reason the forum ceased to exist, not quite like Ranfft's, that didn't disappear but much less usable. Then that is sad, such a massive loss of communication between good people and a wealth of knowledge lost. There should be something in place for when that happens which could be next week, next year or in 10 years. Might not be a topical subject for a lot of folk or boardering on controversy, i did say i talk about stuff other people dont. But if you dont talk about it and something happens then you've lost it and you ain't gonna fix it .
    • I've remained silent on this thread, and at the risk of upsetting everyone, the thing that worries me the most the the apparent absence of Mark. The moderators do a great job and the members also pitch in, and the site seems to run itself, but it is a concern for the future of this forum when the owner is absent for all intents and purposes. Like many of the comments above I would hate to log in one day and things be closed down as I rely on this site for ideas and knowledge and also cheer me up. maybe the Moderators could reach out to him, assuming he does not read this thread, and express our concerns and let us know the plans going forward? some kind of WRT ark
    • That was the exact reason for me starting this thread watchie. Still we haven't worked out how the regulars are going to hook up if it goes tits up. I honestly think something should be arranged to stay in contact, we all help each other so much. 
    • Yeah ive watched that a few times before,  i couldnt find my old school dividers to scribe it up 😅 Yep thats the guy i bought a roll from . Thanks Nicklesilver that answers that perfectly and more or less what i thought an experiment over time would prove . The jumper arm is quite thick along its length, i left it that way intentionally, i thought the original was probably very thin, i didnt see that it was already missing. Setting isn't particularly stiff as such just positive, i still need to take it out and polish where it mates with the stem release. 
    • Yes, "Sold out" is difficult to understand. There doesn't seem to be a lot going on. It's been nine months since any new video was published on the Watch Repair Channel. The Level 4 course on watchfix.com has been in progress for what feels like forever (several years!?). Maybe Mark's enterprises aren't doing well or perhaps already so profitable there's nothing much to motivate him for more material. Or, perhaps these days he's more into crochet. The real reason is probably something entirely different but it would be nice/interesting to know. I don't mean to sound gloomy or pessimistic, but I wouldn't be surprised to be met by an HTTP 404. Every day feels like a gift. Speaking of watchfix.com I've been postponing the "Level 5: Servicing Chronograph Watches" course for a very, very long time. Anyway, I just enrolled on it so it's going to be very interesting to see the videos. I must say, IMO there's nothing really that can compete with Mark's courses when it comes to presentation and video quality. It's simply world-class and makes me associate with some really expensive BBC productions.
×
×
  • Create New...